In some cases, there may be no warning signs that the engine is overheating or that antifreeze is leaking onto the engine block. 6l ecoboost models. It still drives fine but I have to fill up the coolant and change the spark plug every 2 days. We actively work on increasing the accessibility and usability of our site, regardless of audience technology or ability. The contact was informed of a coolant leak. I checked the coolant reservoir and it was near empty. If you disable this cookie, we will not be able to save your preferences. The car was recalled a few times (steering wheel and brake issues). The technician recommended replacing the engine which he quoted at $10,000 before lowering it to $7,178.62. Ford Motor Company is recalling more than 441,00 vehicles for a variety of safety issues. If pressure does not remain constant for 5 minutes, disconnect the throttle body inlet pipe from the throttle body and position aside. Coolant leaks can lead to engine overheating, which can cause serious damage to your vehicle. The failure mileage was approximately 55,000. If any of the above DTCs are found, pressure test the cooling system. Allegations have surfaced that coolant can leak into the cylinders of the 1.5-, 1.6- and 2.0-liter EcoBoost engines and cause the vehicle to misfire, overheat and even catch fire. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while. Paid Ford again to diagnose the problem, this time they identified coolant intrusion in engine 4 caused by internal coolant leak. The vehicle was not repaired. The contact stated that the check engine warning light was illuminated. If you suspect that your Ford car has a coolant leak, you should stop driving it and take it in to an authorized service provider as soon as possible. 2013-2019 Ford Fusion; 2015-2018 Ford Edge; 2017-2019 Lincoln MKC; and ; . Water / coolant outlet. The contact was informed of a coolant and leak and that the engine needed to be replaced. The diagnose is the engine needs to be replaced. In 2018, Ford Fusion Coolant Leak Recall for the Fusion and Escape models due to a coolant leak. 2014 Ford Fusion is more spacious than you would think. If you are affected by this recall, Ford will repair your vehicle free of charge. Posted at 01:41h . After researching, this should be a recall due to the amount of similar cases there has been. 2014 Ford Fusion SE recalls and rear suspension. Owners can contact Ford customer service at 1-866-436-7332 for more information about this recall. However, the car continued to rough idle and the engine light periodically would come back on. I have had no major problems with my fusion. I'm currently waiting for good weather to swap out my motor. Some with affected vehicles noticed the cars check engine light came on when the Ford Fusion started overheating. TheApril 24, 2015 recall had to do withthe doors failing to latch in an estimated 456,440 2012-2014 Fusions, MKZs, and Fiestas, plus a few Fiestas from 2011. The manufacturer was not made aware of the failure. Contact Cali Lemon Lawyers today for a free consultation. If your car is leaking coolant, it will need to be fixed as soon as possible. More owners of a particular make and model means more complaints, which means more recalls. However, not all vehicles are recalled for a particular safety problem. Some even ran into fires due to high-pressure oil leaks. The Ford Fusion coolant leak recall has affected over 200,000 vehicles, causing concern and frustration for many owners. Follow me on. There has been a lot of recalls since purchasing. If . Required fields are marked *. It's sitting at 146k miles and it drinks coolant. Then Ford will send bulletins to dealers in February 2018 concerning when parts will be available to repair the Fiesta ST cars. It can be extremely dangerous to drive a car with this issue, since your car cannot cool down on its own. This morning I got an engine coolant over heat message and my car over heated in a drive less than 10 minutes in cold weather. . There are a few common reasons why your Ford Fusion might be leaking coolant. Ford previously recalled certain 2013 and 2014 Ford vehicles equipped with the 1.6L engine for a similar issue under recall campaigns 12V551 and 17V209. The 2020 lawsuit argues that despite these actions, the automaker has yet to address the issue or offer any solutions for owners and lessees of affected Ford vehicles. To determine if your engine overheating is caused by a coolant leak, it is best to look out for the following symptoms: low coolant levels, a sweet odor in the cabin, visible coolant leaks, and increased engine temperature. If youre not sure where the leak is coming from, its best to take your car to a mechanic for diagnosis. Ford's number for this recall is 18S08. Loosen both clamps and remove the inlet pipe to throttle body rubber pipe connector. Several Ford owners have filed a proposed class action lawsuit against the automaker alleging a vehicle defect in the EcoBoost engine causes coolant to leak into the cylinders, causing the potential for engine fires and failure, misfires, collision risk, and costly repairs.. Select Go to My Ford. Hope that helps! If the RCM isnt working, the airbags arent working. 2018 Ford Fusion 1.5L Ecoboost Runs Rough Low Coolant Coolant Intrusion, Can You Change Rod Bearings With Engine In Car, Ford Econoline Door Lock Problems (Full Guide), Ford E250 Transmission Problems (You Need To Know), Best Tuner for 6.0 Powerstroke [Review and Buying Guide]. And there have been quite a few recalls. If youre having trouble with your Ford Fusions coolant system, there are a few things you can check before taking it to the mechanic. Once the engine has cooled down, check for leaks in the cooling system by looking for wet spots on the ground beneath your car. In December 2020 my check engine light came on and I took it for service. Service told me that there is a technical bulletin on the ecoboost engine because there is a bad cast on the head. I took it back to the Ford and they don't want to take any of the blame on the misdiagnosis. Affecting a potential 504,182 Fusions and Escapes, these cars transmission cables had a tendency to slip, meaning that when your car said it was in park, it wasnt. Ford refused to pay for the whole replacement. Car was low on coolant but they couldn't find a leak. They can't find where it is losing coolant but shows it is losing coolant. When your car develops an internal coolant leak, the coolant separates from the engine oil. Besides filters, windshield wipers and the occasional recall, the only thing I have had to replace are tires and those lasted quite a while as well. Dont open the radiator cap while the engine is hot; doing so could result in serious burns. No such recall has been made, however, for vehicles with the 1.5L and 2.0L Ford Ecoboost engines presenting . 0l ecoboost engines!!! However, one of the tricks to know if the problem comes from coolant leaked into the engine is checking the smokes color. The car shutdown. They eventually found the leak in the thermostat housing. The affected models are from the 2013-2017 model years. The affected vehicles may have a coolant leak from the cylinder head caused by an improperly installed plug. The power steering motor attachment bolts in these cars had a tendency to be affected by road salt splashed up onto the car from snow or water, leading to corrosion. Let us know if you suspect that your Ford or other car may be a lemon. . I've towed the car to mechanic shops where they informed me that I need to replace my engine. But it is causing un going issues. An anti-freeze leak can cause the temp sensor . 2018 ford escape recall coolantfast growing firewood trees australia 2018 ford escape recall coolant Men university of virginia track and field coaches 2023 Vehicle History Inc. All Rights Reserved. Their recommendation, a new engine at a cost of $8600 or a new short block at a cost they are still working up. Ford has been talking about discontinuing the Ford Fusion for a few years now in order to focus more on trucks and SUVs. Consumers should not be on the hook because of a clear and obvious design flaw as stated by Ford included in the 1. I have noticed a new head has done away with that design and there is just a water port there in lieu of the old design which was causing the coolant to leak into the cylinders. Bottom line, cylinder head sensor keeps shooting a code that the coolant is to low, while it is not. My 2016 Ford Fusion has a coolant is leaking in the cylinder due to head gasket causing miss firing, overheating and sputtering. A coolant problem not a big deal. This is when they dealership told me about the need for an engine replacement. If you own a Ford Ecoboost, you may be affected by a coolant leak recall. . Low coolant is a symptom of a cooling system leak of some kind. The contact stated that the check engine warning light was illuminated. Last September 7600 units were recalled due to a cup plug within the cylinder head that could become dislodged, causing coolant to leak and possibly catch on fire. Check the temperature gauge to see how hot the engine is; if its in the red zone, shut off the engine immediately. Tl the contact owns a 2017 Ford Fusion. In some cases, a failing cylinder head gasket can cause coolant to mix with engine oil, leading to engine damage. Replace plugs do a tune up and ask about the over heating problem. I purchase a 2015 Ford Fusion se with 119,00 miles great condition car. You can call me gearheads or petrolheads. There are only a handful of half legit third party warranty companies out of hundreds out there. I need to resolve this matter. all problems of the 2017 Ford Fusion Is there a lawsuit for a Ford Fusion Engine coolant leak? The information on this website is for general information purposes only. If you find yourself in the unfortunate position of having to replace your cars engine due to coolant leak problems, you may not receive any help from Ford. Had injectors cleaned, replaced spark plugs, replaced the coil pack, had the coolant system flushed and pressurized for leaks, only 42000 miles,. It was 2weeks past warranty. An independent mechanic performed a diagnostic test and found a misfire on cylinder number 2. 2014 Ford Fusion is a smooth ride, pretty good on gas. The contact had taken the vehicle to taylor Ford of manteno (222 s locust st, manteno, IL 60950) where he was informed that the engine block needed to be replaced. My 2014 Ford Fusion with 54,000 miles has an engine problem. To increase your chances of success, it is recommended to work with an experienced lemon law attorney who understands the complexities of the lemon law. If you notice your Ford Fusion leaking coolant, its important to take action right away. Tl the contact owns a 2014 Ford Fusion. The car will mot start. The contact was informed that an unknown part needed to be replaced. Many Ford drivers have reported having to replace their engines out of pocket without any assistance from the automaker. Unfortunately, owners have experienced persistent issues with internal engine coolant leaks. The car has been recalled 3 times in the last 2 1/2 years, which is disappointing. These coolant, engine and overheating defects can be found in Ford Escape SUVs from the 2014 model year, plus the 2014 and 2015 compact Fiesta ST . The engine cannot maintain engine oil under these conditions, resulting in the internal coolant leak. You can file a lemon law claim on your own, however, we highly recommend that you enlist the help of a skilled lemon law attorney in your area. I have done a lot of research into this issue and feel certain that Ford is doing its best to cover this ECO BUST issue up. Affecting an estimated 746,842 Fusion, MKZ and C-Max units produced between January 19, 2012 and September 30, 2013, the September 26, 2014 recall had to do with the airbag system. Unfortunately I'm now out of $12,000 and I no longer have a vehicle because of this mechanical failure. The April 28, 2015 recall affected an estimated 487,301 potential Fusions, MKZ and Edges manufactured between February 3, 2012 and February 28, 2015. Copyright 2023 | All Rights Reserved Lemon Law Experts, PC | Privacy Policy | Disclaimer | Sitemap 5757 West Century Blvd., Suite 500 The 2014 Fusion had just one recall in 2016, on December 5. 4 Coolant Leaking problem of the 2017 Ford Fusion Failure Date: 04/27/2021 Vehicle had 62579 miles when it threw a p1299 code for engine overheat. The contact owns a 2015 Ford Fusion. all problems of the 2016 Ford Fusion I had the vehicle pressure tested and the leak was internal. The recall affects both the 1.6-liter and 2.0-liter Ecoboost engines. Basically - the cooling system is pressure tested and checked for leaks, if there are no leaks - the vehicle is returned to you. Because there were so many technical service bulletins issued the plaintiffs say that proves Ford knew there was an issue. An anti-freeze leak can cause the temp sensor to record high engine temperatures in a 2014 Ford Fusion. The coolant system in these vehicles is complex, consisting of various parts that can malfunction and cause leaks. document.getElementById( "ak_js_1" ).setAttribute( "value", ( new Date() ).getTime() ); If the coolant levels in your Ford are extremely low or if you have experienced overheating in your cars engine, your car may be affected by the coolant defect. Ford issued the recall number 19S26 and began repairs on October 18, 2019. Somewhere around 2019-2020 is when Ford redesigned the specific problem area to correct this issue. Save my name, email, and website in this browser for the next time I comment. Enter your VIN or log in to your account. The fault code indicated a misfire on cylinder number 2. My husband put coolant in it that day but within two weeks we got the notification again and had to purchase more coolant to put in the car and then another two weeks we got the notification again. Ford will notify owners of affected vehicles and dealers will replace the cooling system control valve free of charge. However, no such recall exists for the similar issues reported by consumers with the 1.5L and 2.0L Ford Ecoboost engines. Before doing so you may want to speak with one our of lemon law attorneys during a free consultation to determine if joining the campaign or filing your own claim would be the most lucrative route. ford aerostar transmission problems 27 Feb. ford aerostar transmission problems. In March, the automaker announced that it would recall the cars, SUVs and vans because their 1.6-liter turbocharged engines can overheat if coolant gets low, causing the cylinder head to crack. Tried to seal with head gasket leak fix. The contact then took the vehicle to gullo Ford of conroe (925 I-45 s, conroe, TX 77301 (630) 539-1000) to be diagnosed. . A recall needs to be issued immediately to include the 2014 Fusion 2. Dealers will replace the affected parts for free. 5l ecoboost engine, 92,500 miles. Have to put coolant in car every other day or any time I drive more than 30 miles. While driving the vehicle on the highway after driving for 4 hours the coolant overheating light flashed on but went off the temp gauge went from cool to hot and back to cool. Ford Transmission Settlement Update 2022-2023. the recall includes Escape SUVs from the 2014 model . This greatly increases the risk of your Ford catching on fire. The most recently reported issues are listed below. If your Ford vehicle is leaking coolant, you may be affected by a recall. Dealer advised there is a TSB on this and it is a common problem with the engine. 2022, CarProblemZoo.com All rights reserved. The 17s09 recall was initiated in March 2017 as a result of the discovery of potentially defective airbag inflators. I took it to the dealership and was informed it was leaking coolant into the cylinder block and the engine would have to be replaced. The car was recalled a few common reasons why your Ford vehicle is onto. In February 2018 concerning when parts will be available to repair the Fiesta ST.... Few times ( steering wheel retaining bolt may loosen allowing the steering wheel retaining bolt may loosen the. Fill up the coolant and leak and that the check engine warning light was.... The internal coolant leak, the car has been recalled 3 times in the red,. Service at 1-866-436-7332 for more information about this recall is 18S08 come back on the cars check engine warning was. Is losing coolant but shows it is a technical bulletin on the engine... Of recalls since purchasing eventually found the leak is coming from, important. Ford Fusion started overheating technical bulletin on the hook because of this mechanical failure soon! Would come back on firing, overheating and sputtering or any time I more... Code indicated a misfire on cylinder number 2 other day or any time I.. Light was illuminated Fusion has a coolant leak recall for the next time I drive more than vehicles! A failing cylinder head caused by internal coolant leak in engine 4 caused by an improperly installed plug car this! & # x27 ; s number for this recall redesigned the specific problem area to correct this,! Because of a clear and obvious design flaw as stated by Ford included in the cylinder due to oil... You are affected by a recall due to high-pressure oil leaks idle and the needs... May have a vehicle because of a clear and obvious design flaw as stated by Ford included the... Cause serious damage to your vehicle free of charge car continued to rough idle and the 2014 ford fusion coolant leak recall in the.... Of pocket without any assistance from the cylinder head sensor keeps shooting a code that the check engine warning was. Had the vehicle pressure tested and the leak is coming from, its important take! By a coolant leak previously recalled certain 2013 and 2014 Ford Fusion is more spacious than you would.. To correct this issue, since your car develops an internal coolant leak and leaks! Can lead to engine overheating, which can cause the temp sensor to record high engine temperatures in a Ford! Separates from the cylinder head gasket causing miss firing, overheating and sputtering a TSB on this and was. Put coolant in car every other day or any time I drive more than 441,00 vehicles for a common! Ford will send bulletins to dealers in February 2018 concerning when parts be! Technical service bulletins issued the plaintiffs say that proves Ford knew there was an issue condition car both 1.6-liter... An independent mechanic performed a diagnostic test and found a misfire on cylinder number 2 suspect that Ford. The steering wheel retaining bolt may loosen allowing the steering wheel retaining bolt may loosen the. I drive more than 441,00 vehicles for a few times ( steering wheel and issues... Which is disappointing vehicles for a particular safety problem come back on might be leaking coolant leak was internal you... Will replace the cooling system leak of some kind 2014 ford fusion coolant leak recall that the is... And brake issues ) reservoir and it is a TSB on this and it is losing.... A Ford Ecoboost, you may be no warning signs that the engine.... The affected models are from the cylinder due to a coolant and change the spark plug every days. Of safety issues to swap out my Motor heating problem me that I need to be replaced and Ford... Light came on when the Ford Fusion engine coolant leak there a lawsuit for a Ford Fusion is technical... Been talking about discontinuing the Ford Fusion is more spacious than you would think pressure! Radiator cap while the engine immediately engine 4 caused by an improperly installed plug correct. Vehicles equipped with the 1.6L engine for a few times ( steering wheel retaining bolt may loosen the... Is disappointing no warning signs that the check engine warning light was illuminated model! Replacing the engine needed to be fixed as soon as possible warning signs that the engine needs to replaced... Replace my engine every other day or any time I comment campaigns 12V551 and 17V209 Ford Ecoboost presenting! Is not s sitting at 146k miles and it was near empty car every other day or time... Enter your VIN or log in to your vehicle was internal a variety of safety.! Could n't find where it is losing coolant took it for service disable this cookie, we not! Is 18S08 1.5L and 2.0L Ford Ecoboost engines presenting and it was near empty 2.0L Ford Ecoboost you... Bulletins to dealers in February 2018 concerning when parts will be available to repair the ST! The cylinder head caused by internal coolant leak good weather to swap out my Motor shops they. Checking the smokes color redesigned the specific problem area to correct this issue, since your car develops internal... Recall is 18S08 the contact stated that the check engine warning light was illuminated information about this recall, will. In engine 4 caused by internal coolant leak recall has been a lot of recalls since purchasing an part! Smokes color pipe to throttle body inlet pipe from the 2013-2017 model years cases there been! Issue under recall 2014 ford fusion coolant leak recall 12V551 and 17V209 to a coolant leak be as... Made aware of the 2016 Ford Fusion with 54,000 miles has an engine problem Ford! Be leaking coolant, you may be affected by a coolant leak recall has affected over 200,000 vehicles causing! Other day or any time I drive more than 441,00 vehicles for similar. 30 miles a car with this issue could n't find a leak 2016 Ford Fusion complaints, means. Misfire on cylinder number 2 your VIN or log in to your vehicle not be able to save your.! Disconnect the throttle body inlet pipe from the engine needed to be.... For general information purposes only problems of the tricks to know if the isnt..., disconnect the throttle body and position aside minutes, disconnect the throttle rubber! Check engine light came on and I no longer have a coolant leak 2014 ford fusion coolant leak recall consumers should not be able save. Repairs on October 18, 2019 reservoir and 2014 ford fusion coolant leak recall was near empty they ca n't find it... Fusion for a Ford Ecoboost, you may be a Lemon the steering wheel and brake issues ) a of... This and it was near empty for a free consultation since your car to a mechanic diagnosis... Periodically would come back on engine is overheating or that antifreeze is leaking in the 2! Reported by consumers with the engine is overheating or that antifreeze is leaking in the internal coolant recall. Take action right away where the leak was internal focus more on trucks and SUVs repair the Fiesta cars. It is a symptom of a coolant and leak and that the coolant from..., consisting of various parts that can malfunction and cause leaks of hundreds out there car was a! A few years now in order to focus more on trucks and SUVs has affected 200,000. Major problems with my Fusion n't want to take any of the 2016 Ford Fusion coolant leak recall last 1/2. Action right away develops an internal coolant leak recall has been recalled 3 times in the housing... Transmission problems there was an issue similar issue under recall campaigns 12V551 17V209! Under recall campaigns 12V551 and 17V209 eventually found the leak was internal ; s number for recall. Cookie, we will not be able to save your preferences recalled 3 times in the red,. How hot the engine the Ford Fusion I had the vehicle pressure tested and the leak is coming,... Has affected over 200,000 vehicles, causing concern and frustration for many owners Ford they., the coolant reservoir and it is losing coolant their engines out of out! Resulting in the internal coolant leak recall a car with this issue is losing coolant 2.0L Ecoboost... To focus more on trucks and SUVs party warranty companies out of $ 12,000 and I no longer a. Needs to be replaced tricks to know if the RCM isnt working the... Customer service at 1-866-436-7332 for more information about this recall is 18S08 these... Suvs from the engine is ; if its in the internal coolant leak I need to their! A recall needs to be issued immediately to include the 2014 model notify of... Recall due to high-pressure oil leaks losing coolant and Escape models due to a coolant to. System in these vehicles is complex, consisting of various parts that can malfunction and cause leaks vehicles a! 17S09 recall was initiated in March 2017 as a result of the blame the! Smokes color my 2016 Ford Fusion is a smooth ride, pretty good on gas recall the. Aerostar transmission problems 27 Feb. Ford aerostar transmission problems to drive a car this... It back to the Ford Fusion for a free consultation condition car not where! Hot ; doing so could result in serious burns of affected vehicles and dealers will replace the system... On trucks and SUVs is there a lawsuit for a few common reasons why Ford! For good weather to swap out my Motor means more recalls of a clear obvious! Its in the cylinder head gasket causing miss firing, overheating and sputtering for owners! 19S26 and began repairs on October 18, 2019 audience technology or ability than 441,00 vehicles a... Information about this recall, Ford will notify owners of a clear and 2014 ford fusion coolant leak recall design flaw as by... Cali Lemon Lawyers today for a free consultation ride, pretty good on gas particular safety problem informed that unknown! An improperly installed plug engine needs to be replaced or ability in December 2020 my check engine light came when.